2002 Chevrolet Impala A/C-HEATER SYSTEMS Removal
download 1. Remove the following component: For a 3.4L engine, remove the air cleaner assembly. For a 3.8L engine, remove the fuel injector sight shield. 2. Drain the coolant. Use Hose Clamp Pliers in...
View Article1996 Lincoln Town Car Heater Core Removal
download 1. Remove the heater air plenum chamber (18471) assembly as outlined. 2. Remove the four retaining screws from the heater core cover (18B300) and remove the heater core cover from the heater...
View Article1992 Ford Taurus Heater Core: Service and Repair With Manual A/C
download NOTE: Vehicles may be equipped with an aluminum or a copper brass heater core. Use replacement cores made of copper brass. Always identify the type of core being replaced because there is a...
View Article2002 Chrysler Voyager Front Evaporator Core Replacement
download REMOVAL WARNING: REFER TO THE APPLICABLE WARNINGS AND CAUTIONS FOR THIS SYSTEM BEFORE PERFORMING THE FOLLOWING OPERATION. 1. Remove the HVAC unit housing from the vehicle. See: Housing...
View Article2000 Ford Expedition Evaporator Core REMOVAL AND INSTALLATION
download Removal and Installation NOTE: If an A/C evaporator core leak is suspected, the A/C evaporator core must be leak tested before it is removed from the vehicle. For additional information, refer...
View Article1991 Chevy G 20 Van Heater Core: Service and Repair Primary (Front) Heater Core
download Remove or Disconnect (Figures 5 through 10 and Figure 20) 1. Battery ground cable. 2. Coolant recovery tank. 3. Heater core hoses (140 and 141) (figures 6, 7, 8 and 20). ^ Place a clean pan...
View Article2000 Jeep Grand Cherokee Heater Core: Service and Repair
download REMOVAL 1. Remove the heater-A/C housing from the vehicle. See: Housing Assembly HVAC/Service and Repair 2. Remove the foam gasket surrounding the core tubes. NOTE: Notice the orientation of...
View Article2001 Ford Taurus V6-3.0L DOHC With Damaged Evaporator Core Orifice Service...
download SPECIAL TOOL(S) 1. Remove the condenser to evaporator line. 3. Index mark the condenser to evaporator line. Disconnect the two halves of the condenser to evaporator line. 4. Inspect the...
View Article2003 Pontiac Grand Prix Heater Core Replacement
download Tools Required J 38185 Hose Clamp Pliers Removal Procedure 1. Remove the fuel injector sight shield (3.8L only). Refer to Fuel Injector Sight Shield Replacement in Engine Mechanical-3.8L. 2....
View Article2001 Mazda B3000 SE Regular Cab How to EVAPORATOR CORE REMOVAL / INSTALLATION
download To prevent system contamination, whenever the evaporator core is replaced, also replace the receiver/drier. NOTE: The evaporator core is not separately serviceable, it is serviced only with...
View Article